Ruggedness of Visible-Residue Limits for Cleaning (Part II) - Pharmaceutical Technology

Latest Issue

Latest Issue
PharmTech Europe

Ruggedness of Visible-Residue Limits for Cleaning (Part II)
The author challenges current detection methodologies.

Pharmaceutical Technology
Volume 35, Issue 3, pp. 122-128

Results and discussion

Table VI: Visible-residue limit (VRL) determination.
The results of the VRL determinations for both the random and sequential presentations are shown in Table VI. The random coupon presentation provided comparable results to the sequential coupon presentation. For both the sequentially and the randomly presented coupons, the experimentally determined VRLs were lower than the previously determined VRLs for three of the compounds and higher for the fourth. The lower VRLs resulted from spotting lower concentrations than in the initial VRL determination. The initial determinations were deemed acceptable because they were sufficiently lower than the swab limit or ARL (2). The sample preparation used for the more recent VRL determinations resulted in lower overall VRLs and a more rugged data set (6).

Figure 2: Sequential coupon presentation.
Aside from the presentation of the coupons, the other significant difference was the number of blank coupons presented. The VRL determination using the random coupon presentation involved a greater number of blank coupons (i.e., nine) than did the sequential coupon presentation (i.e., four). It was felt that the additional blank coupons would increase the physical separation of the soiled coupons, limit direct side-by-side comparisons of the soiled coupons, and enable a more independent assessment of each of the individual soiled coupons.

The consistent results obtained using either method of coupon presentation answered a long-standing question. The sequential coupon presentation raised a concern that the decreasing residue concentrations and the close proximity of adjacent residues might lead observers to see residues where they might not ordinarily have identified a visible residue.

Because the two methods of coupon presentation result in the same VRL, which way should one present coupons for VRL determinations? The sequential coupon presentation offers marginal advantages in the following areas.

  • It provides ease of setup and recording. The random coupon presentation requires slightly more paperwork with its matrix approach.
  • It is easier to do one or more multiple compounds/residues at a time. The random approach is more suited to multiple determinations.
  • It makes more efficient use of coupons, because the random approach will use additional coupons to fill in the square matrix as necessary.

As noted above, the primary advantage of the random presentation was to increase the physical separation of the soiled coupons and limit direct side-by-side comparisons.

To ensure rugged, reproducible results, however, the observers must be thoroughly trained. It is always emphasized during training that the VRL is a physical property of the residue and that the ability to see every spotted residue is not an expectation. Observers are then more likely to report what they see rather than what they think they are expected to see. Therefore, the optimal coupon presentation depends on the level of training for the coupon preparation and the observers. For newly trained personnel, the random coupon presentation might be appropriate, and the sequential coupon presentation might be more appropriate for more experienced personnel.


blog comments powered by Disqus
LCGC E-mail Newsletters

Subscribe: Click to learn more about the newsletter
| Weekly
| Monthly
| Weekly

What role should the US government play in the current Ebola outbreak?
Finance development of drugs to treat/prevent disease.
Oversee medical treatment of patients in the US.
Provide treatment for patients globally.
All of the above.
No government involvement in patient treatment or drug development.
Finance development of drugs to treat/prevent disease.
Oversee medical treatment of patients in the US.
Provide treatment for patients globally.
All of the above.
No government involvement in patient treatment or drug development.
Jim Miller Outsourcing Outlook Jim MillerCMO Industry Thins Out
Cynthia Challener, PhD Ingredients Insider Cynthia ChallenerFluorination Remains Key Challenge in API Synthesis
Marilyn E. Morris Guest EditorialMarilyn E. MorrisBolstering Graduate Education and Research Programs
Jill Wechsler Regulatory Watch Jill Wechsler Biopharma Manufacturers Respond to Ebola Crisis
Sean Milmo European Regulatory WatchSean MilmoHarmonizing Marketing Approval of Generic Drugs in Europe
FDA Reorganization to Promote Drug Quality
FDA Readies Quality Metrics Measures
New FDA Team to Spur Modern Drug Manufacturing
From Generics to Supergenerics
CMOs and the Track-and-Trace Race: Are You Engaged Yet?
Source: Pharmaceutical Technology,
Click here